Scientific Experiences in Energy and Thermal Engineering

Articles

Utilization of the Refrigeration Effect from LPG Expansion for a Refrigerated Display Cabinet (RDC): An Experimental Study of a Half-Cycle System

Muhammad Latifur Rochman , Muhammad Galang Azrul Kurniawan , Kiswantoro , Bayu Aji Saputro , Fungky Dyan Pertiwi , Bagiyo Condro Purnomo , Ilham Habibi , Rachmadian Wulandana

Published
January 2, 2027

Vol. 1 No. 1 (2027): Issue in Progress
Pages e23.1-13

DOI

Open Access
Download PDF
Share

Abstract

Energy demand for commercial refrigeration continues to rise alongside the global transition toward environmentally benign natural refrigerants, while conventional cooling systems for refrigerated display cabinets (RDCs) remain heavily dependent on electricity and synthetic refrigerants. This study investigates the utilization of the refrigeration effect arising from the pressure reduction of LPG (a propane-butane mixture) prior to combustion, known as a half-cycle refrigeration system, as an alternative cooling source for a small-scale (192 L) beverage RDC. Liquid LPG is expanded isenthalpically through an expansion valve into an evaporator placed inside the RDC, while the resulting LPG vapor is routed to a burner. Testing was conducted for 60 minutes with data logged at 1-minute intervals using PT100 RTD sensors, PSAN pressure transducers, and humidity sensors connected to an Autonics data acquisition system. Results show the system reaches quasi-steady state within ±10 minutes on the refrigerant side, with an actual cooling power of ±263 W based on the measured LPG mass flow rate (3.07 kg/h) and a specific refrigeration effect of ±309 kJ/kg. Although only ±1.23% of this cooling capacity was utilized as net RDC air energy reduction, indicating a substantial parasitic heat load from suboptimal insulation, the test RDC successfully reached the operating temperature range of commercial minimarket RDCs (5.4–8.3 °C, verified via thermal imaging) within the test duration. These findings thermodynamically demonstrate that the otherwise-wasted LPG refrigeration effect has potential as a supplementary (pre-cooling/auxiliary) cooling system for small-to-medium beverage RDCs, particularly for businesses that already consume LPG routinely, while pointing toward further research on insulation optimization and frost management for broader commercial application.

Keywords

LPG; Half-cycle refrigeration system; Refrigerated display cabinet; Cooling effect; Energy efficiency

References

  1. M. S. Stephen, S. A. Valsalan, and H. N. Ramanathan, “Energy consumption in seafood freezing: An analysis on production capacity and freezer type,” Next Energy, vol. 12, p. 100620, 2026, doi: 10.1016/j.nxener.2026.100620.
  2. S. Bobbo, G. Lombardo, D. Menegazzo, L. Vallese, and L. Fedele, “A Technological Update on Heat Pumps for Industrial Applications,” 2024. doi: 10.3390/en17194942.
  3. A. Mota-Babiloni and P. Makhnatch, “Predictions of European refrigerants place on the market following F-gas regulation restrictions,” International Journal of Refrigeration, vol. 127, pp. 101–110, 2021, doi: 10.1016/j.ijrefrig.2021.03.005.
  4. O. A. A.-M. Ibrahim et al., “Hydrocarbon refrigerants as sustainable alternatives to high-GWP refrigerants: a systematic review of R600 and R600a,” Journal of Thermal Analysis and Calorimetry, vol. 150, no. 21, pp. 17185–17206, 2025, doi: 10.1007/s10973-025-14831-3.
  5. O. A. A.-M. Ibrahim, S. A. Kadhim, K. A. Hammoodi, F. L. Rashid, and A. H. Askar, “Review of hydrocarbon refrigerants as drop-in alternatives to high-GWP refrigerants in VCR systems: The case of R290,” Cleaner Engineering and Technology, vol. 23, p. 100825, 2024, doi: 10.1016/j.clet.2024.100825.
  6. D. Wu, B. Hu, and R. Z. Wang, “Vapor compression heat pumps with pure Low-GWP refrigerants,” Renewable and Sustainable Energy Reviews, vol. 138, p. 110571, 2021, doi: 10.1016/j.rser.2020.110571.
  7. F. Alsouda, N. S. Bennett, S. C. Saha, F. Salehi, and M. S. Islam, “Vapor Compression Cycle: A State-of-the-Art Review on Cycle Improvements, Water and Other Natural Refrigerants,” 2023. doi: 10.3390/cleantechnol5020030.
  8. R. Yıldırım, A. Akyüz, K. Kumaş, A. D. Tuncer, and A. Gungor, “A comprehensive overview of refrigerants from the past to the modern day: energy, exergy, and environmental perspectives,” Journal of Thermal Analysis and Calorimetry, vol. 150, no. 5, pp. 3201–3223, 2025, doi: 10.1007/s10973-025-14050-w.
  9. G. H. Kang, S.-I. Na, and M. S. Kim, “Reasonable performance comparison for a refrigeration system using different refrigerants: Case with propane and isobutane mixtures with several compositions,” International Journal of Refrigeration, vol. 135, pp. 41–50, 2022, doi: 10.1016/j.ijrefrig.2021.12.006.
  10. M. Ozsipahi, H. A. Kose, H. Kerpicci, and H. Gunes, “Experimental study of R290/R600a mixtures in vapor compression refrigeration system,” International Journal of Refrigeration, vol. 133, pp. 247–258, 2022, doi: 10.1016/j.ijrefrig.2021.10.004.
  11. D. Cai, Z. Hao, H. Xu, and G. He, “Research on flammability of R290/R134a, R600a/R134a and R600a/R290 refrigerant mixtures,” International Journal of Refrigeration, vol. 137, pp. 53–61, 2022, doi: 10.1016/j.ijrefrig.2022.02.015.
  12. M. Wei et al., “Benefits and challenges in deployment of low global warming potential R290 refrigerant for room air conditioning equipment in California,” Sustainable Energy Technologies and Assessments, vol. 70, p. 103937, 2024, doi: 10.1016/j.seta.2024.103937.
  13. L. Vaitkus, L. Prakopavičius, and A. Balčius, “Refrigerants for eutectic refrigerating systems–Experimental results and future consideration,” International Journal of Refrigeration, vol. 164, pp. 105–116, 2024, doi: 10.1016/j.ijrefrig.2024.04.012.
  14. A. M. Ashour, S. A. Kadhim, H. M. Jaffar, O. A. A.-M. Ibrahim, A. Mota-Babiloni, and A. Bouabidi, “Experimental investigation of the performance of vapor compression cycle in a water cooler system with low-GWP alternative refrigerants,” Thermal Science and Engineering Progress, vol. 62, p. 103611, 2025, doi: 10.1016/j.tsep.2025.103611.
  15. Z. Hou, Z. Yang, H. He, Y. Zhao, and S. Zhang, “Experimental study on the thermal performance of the isobutane in lubricants for refrigeration and air conditioning applications,” Applied Thermal Engineering, vol. 302, p. 131956, 2026, doi: 10.1016/j.applthermaleng.2026.131956.
  16. D. Calleja-Anta, D. Sánchez, L. Nebot-Andrés, R. Cabello, and R. Llopis, “Alternative mixtures to R-600a. Theoretical assessment and experimental energy evaluation of binary mixtures in a commercial cooler,” International Journal of Refrigeration, vol. 152, pp. 83–92, 2023, doi: 10.1016/j.ijrefrig.2023.05.009.
  17. S. A. Kadhim, “Thermodynamic and environmental analysis of hydrocarbon refrigerants as alternatives to R134a in domestic refrigerators,” International Journal of Thermodynamics, vol. 27, no. 2, pp. 10–18, 2024, doi: 10.5541/ijot.1368985.
  18. S. G. Hacıpaşaoğlu and İ. T. Öztürk, “Methods to increase the coefficient of performance of refrigeration cycles in low-temperature applications : a review,” Engineering Research Express, vol. 7, 2025, doi: 10.1088/2631-8695/adc875.
  19. B. Şensoy et al., “Experimental analysis of energy-saving and eco-friendly refrigeration system design with condensate water management,” Applied Thermal Engineering, vol. 271, p. 126315, 2025, doi: 10.1016/j.applthermaleng.2025.126315.
  20. A. Mota-Babiloni, J. Navarro-Esbrí, Á. Barragán-Cervera, F. Molés, B. Peris, and G. Verdú, “Commercial refrigeration – An overview of current status,” International Journal of Refrigeration, vol. 57, pp. 186–196, 2015, doi: 10.1016/j.ijrefrig.2015.04.013.
  21. H. Demirpolat, “The energy efficiency and environmental analysis of open-type commercial display cabinet with a multi-flow air curtain design,” Sustainable Energy Technologies and Assessments, vol. 60, p. 103555, 2023, doi: 10.1016/j.seta.2023.103555.
  22. Y. Wang, Y. Zheng, X. Hu, S. Liu, X. Li, and Q. Wang, “Impact of condensate water recycling on the performance of open refrigerated display cabinet,” Case Studies in Thermal Engineering, vol. 54, p. 104022, 2024, doi: 10.1016/j.csite.2024.104022.
  23. T. Vengalis and V. Mokšin, “Experimental and Numerical Study of the Performance of an Open-Type Multi-Deck Refrigerated Cabinet with Single and Dual Air Curtain,” 2023. doi: 10.3390/app13169080.
  24. I. N. Suamir, M. E. Arsana, and K. M. Tsamos, “Experimental study on the influences of air flow in an integral hydrocarbon display cabinet to its temperature and energy performances,” in IOP Conference Series: Materials Science and Engineering, IOP Publishing, 2019, p. 12017. doi: 10.1088/1757-899X/494/1/012017.
  25. [25] C. Piselli, C. Balocco, S. Forastiere, A. Silei, F. Sciurpi, and F. Cotana, “Energy efficiency in the commercial sector. Thermodynamics fundamentals for the energy transition,” Energy Reports, vol. 11, pp. 4601–4621, 2024, doi: 10.1016/j.egyr.2024.04.033.
  26. R. A. Kishore et al., “Experimental characterization and analysis of phase change material-based thermal energy storage system for refrigerated display case,” Energy Conversion and Management, vol. 353, p. 121143, 2026, doi: 10.1016/j.enconman.2026.121143.
  27. Direktorat Jenderal Minyak dan Gas Bumi, “Spesifikasi Bahan Bakar Gas Jenis Liquified Petroleum Gas No. 26525.K/10/DJM.T/2009,” 2009, Kementerian Energi dan Sumber Daya Mineral Republik Indonesia, Jakarta.
  28. R. A. Fauzi, “Pendeteksi kebocoran gas menggunakan sensor MQ-2 berbasis Arduino Uno,” Jurnal Teknik Informatika, vol. 12, no. 2, pp. 101–110, 2024. M. Setiyo, S. Soeparman, and N. Hamidi, “Numerical Study on Cooling Effect Potential from Vaporizer Device of LPG Vehicle,” Journal of Engineering Science and Technology, vol. 12, no. 7, pp. 1766–1779, 2017.
  29. M. Setiyo, N. Widodo, B. C. Purnomo, S. Munahar, M. A. Rahmawan, and A. Luthfi, “Harvesting cooling effect on lpg-fueled vehicles for mini cooler: A lab-scale investigation,” Indonesian Journal of Science and Technology, 2019, doi: 10.17509/ijost.v4i1.12834.
  30. M. Setiyo, B. C. Purnomo, B. Waluyo, D. R. B. Syaka, and N. Hamidi, “Refrigeration effect and energy efficiency ratio (EER) calculation of 1/2 cycle refrigeration system on LPG-fueled vehicles,” in IOP Conf. Series: Materials Science and Engineering, IOP, 2018. doi: 10.1088/1757-899X/403/1/012087.
  31. M. Setiyo, B. Waluyo, and N. Hamidi, “Analysis of Evaporator Effectiveness on 1/2 Cycle Refrigeration Systems: A Case Study on LPG Fueled Vehicles,” Jurnal Teknologi, vol. 82, no. 3, pp. 53–59, 2020, doi: 10.11113/jt.v82.13386.
  32. [33] M. Setiyo et al., “Cooling power characteristics of half-cycle refrigeration system in LPG fuelled vehicles by auxiliary chiller as heat exchanger,” Thermal Science and Engineering Progress, vol. 27, p. 101145, 2022, doi: 10.1016/j.tsep.2021.101145.
  33. B. Waluyo et al., “Cooling effect characteristic of the novel half-cycle refrigeration system on a liquefied petroleum gas (LPG) fueled vehicle,” Thermal Science and Engineering Progress, vol. 34, p. 101405, 2022, doi: 10.1016/j.tsep.2022.101405.
  34. P. N. Ryastama, D. S. Prakasa, M. L. Rochman, and M. Setiyo, “Eksperimen Kinerja Sistem Refrigerasi Setengah Siklus pada Kendaraan Berbahan Bakar LPG,” Jurnal Rekayasa Mesin, vol. 14, no. 1, pp. 181–194, 2023, doi: 10.21776/jrm.v14i1.1197.
  35. M. Mohan, “Zero Cost Refrigeration and Air Conditioning Using LPG,” 2013, Tech Briefs, Chennai. [Online]. Available: http://contest.techbriefs.com/2013/entries/sustainable-technologies/3792
  36. I. H. Shah and K. Gupta, “Design of LPG Refrigeration System and Comparative Energy Analysis with Domestic Refrigerator,” International Journal Of Engineering Sciences & Research Technology, vol. 3, no. 7, pp. 206–213, 2014, [Online]. Available: http://www.ijedr.org/papers/IJEDR1502237.pdf
  37. P. Srinivas, P. R. Chandra, M. R. Kumar, and N. Y. M. Reddy, “Experimental Investigation of LPG as Refrigerant in a Domestic Refrigerator,” Journal of Mechanical Engineering Research and Technology, vol. 2, no. 1, pp. 470–476, 2014.
  38. U. Shahare, K. Yadav, V. Dongre, A. Umre, K. Gajbhiye, and Y. Bhaisare, “Fabrication of Low Cost Refrigeration System by using LPG,” International Journal of Advanced Research in Science, Communication and Technology, vol. 8, no. 1, pp. 282–286, 2021, doi: 10.48175/IJARSCT-1846. G. Ali, A. Muzaffar, T. A. Cheema, and S. F. Shah, “Refrigeration Potential Investigation of Half-Cycle Refrigeration System Using Liquefied Petroleum Gas †,” Engineering Proceedings, vol. 45, no. 1, 2023, doi: 10.3390/engproc2023045044.
  39. M. Manohar, P. K. Sahu, P. Sahu, D. Singh, and A. Chandra, “Design Analysis and Performance of Low Cost Refrigeration System using LPG,” International Journal of Engineering Science and Computing, vol. 10, no. 5, pp. 25633–25636, 2020.
  40. S. J. Kline, “Describing uncertainties in single-sample experiments,” Mech. Eng., vol. 75, pp. 3–8, 1963.
  41. D.-Y. Peng and D. B. Robinson, “A New Two-Constant Equation of State,” Industrial & Engineering Chemistry Fundamentals, vol. 15, no. 1, pp. 59–64, Feb. 1976, doi: 10.1021/i160057a011.
  42. B. E. Poling, J. M. Prausnitz, O. John Paul, and R. C. Reid, The properties of gases and liquids, vol. 5. Mcgraw-hill, New York, 2001.
  43. ASHRAE, ASHRAE Handbook—Fundamentals, Chapter 1: Psychrometrics. Atlanta: American Society of Heating, Refrigerating and Air-Conditioning Engineers, 2021.
  44. A. L. Buck, “New equations for computing vapor pressure and enhancement factor,” Journal of Applied Meteorology and Climatology, vol. 20, no. 12, pp. 1527–1532, 1981, doi: 10.1175/1520-0450(1981)020<1527:NEFCVP>2.0.CO;2.
  45. Y. A. Çengel and M. A. Boles, Thermodynamics: An engineering approach, Eight. McGraw-Hill, 2015.
Article Metrics
0
Views
0
Downloads

SCITE

DIMENSIONS

Publication Information
Published January 2, 2027
Section Articles
Copyright Copyright (c) 2027 Muhammad Latifur Rochman, Muhammad Galang Azrul Kurniawan, Kiswantoro, Bayu Aji Saputro, Fungky Dyan Pertiwi, Bagiyo Condro Purnomo, Ilham Habibi, Rachmadian Wulandana (Author)
License Creative Commons License

This work is licensed under a Creative Commons Attribution-NonCommercial 4.0 International License.
Keywords
  • LPG
  • Half-cycle refrigeration system
  • Refrigerated display cabinet
  • Cooling effect
  • Energy efficiency
Related Articles
Kinetic Analysis of the Combustion Reaction of Sub-Bituminous Coal Blended with Empty Fruit Bunch (EFB) Waste

Alhikami et al.

Vol. 1 No. 1 (2027): Issue in Progress | e17.1-12

Comparative Study of a Biomass-Derived Activated Carbon Catalyst and a Synthetic Silica–Alumina Catalyst on the Heat Transfer Rate Characteristics of Coconut Oil Droplet Combustion

Riupassa et al.

Vol. 1 No. 1 (2027): Issue in Progress